(Tool Needed: Jumper Wire)The brake lever switch informs the speed controller to turn the motor off when the brakes are applied. Checking the continuity of the fuse or circuit breaker with a multimeter is the best way to determine if they are working or not.
(Tool Needed: Multimeter) Sometimes fuses burn-out in a place where you can’t see it, and sometimes circuit breakers will mechanically reset but they are worn-out and still will not work. Motors that smell burned should be replaced to prevent damage to the speed controller. Any components that look burned or melted, or that smell like burned plastic are almost always defective and should be replaced. Get your nose close to the speed controller and motor and smell them. Pull and push on all of the individual wires and wire connectors to make sure they are not loose or disconnected. Also look for loose, disconnected, or damaged wires or wire connectors. Remove the footplate or wiring cover and look for any burned or melted wires, wire connectors, or electrical components. Try charging the battery pack for 8 hours and then see if that helps. Try Charging The Battery Pack for 8 HoursĮlectric scooters that have not been charged for over 3 months will have partially discharged battery packs which may not provide enough power to run the scooter. Once the scooter reaches walking speed and the throttle is engaged the scooter should run until the throttle is released or the brake is used. Stand on the scooter with one foot and push it forward with your other foot while fully engaging the throttle.
For scooters that use a circuit breaker, push-on or flip the circuit breaker to see if it will reset.Įlectric scooters with single speed throttles sometimes need to be pushed forward in order to run. The fuse may need to be removed from the scooter and held up to a source of light to determine if it is burned-out or not. If the scooters uses a fuse, look at the inside of the fuse to see if it is burned-out. When was the last time the battery pack was recharged?īattery Pack Has Been Charged In The Last 3 Monthsĭetermine that the key switch or power switch is in the on position.
Comment Flag.Įlectric Scooter Troubleshooting Guide >Motor Does Not Run > Battery Pack Has Been Charged In The Last 3 Months Clicking this will make more experts see the question and we will remind you when it gets answered. Where can I download a repair manual for a 2012 Tao Tao VIP 49cc scooter? Posted by Anonymous on Jun 15, 2012. Free repair manual Tao Tao VIP 49cc scooter 2012. From the classic look of the NewSpeed 50 to the sleek and modern feel of the Quantum 150, Tao Motor offers a scooter to get across town in style. We have an extensive lineup of quality engineered scooters to suit your tastes and fit your budget.
Tao Motor is among the world’s largest scooter manufacturers.
0 kommentar(er)
